2009 BMW 5 Series: Recalls, Problems & MPG
Here are the deets on the 2009 BMW 5 Series: 3 recalls, 8 owner complaints and up to 21 mpg combined.
_530d_(2008)_(52915567221).jpg){kind=link}
Recalls
3 vehicle recalls from the manufacturer, plus 1 equipment/tire recall that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Brakes (hydraulic) Vehicle recall #10V446000 · 2010 · 198,352 vehicles
What's wrong: A check valve of the brake vacuum pump May leak a small amount of lubricating oil. Over time this could result in contamination of the brake booster.
Why it matters: Power assist braking performance could be adversely affected. In extreme cases there could be a complete loss of power assist braking. An unexpected reduction or loss in power braking assist May increase the risk of a crash.
The fix: Bmw will notify owners and dealers will repair the vehicles free of charge. The safety recall began on November 24, 2010.
Electrical Vehicle recall #12V126000 · 2012 · 367,682 vehicles
What's wrong: The insulated bulkhead connector for the positive battery cable May have been incorrectly attached to the trunk floor panel, which can lead to a loosening of the bolt connection. As it loosens, an increase in electrical resistance at this cable connection is possible and could cause the cable connection to overheat.
Why it matters: Overheating could lead to a fire, even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
The fix: Bmw will notify owners, and dealers will inspect and secure the battery bolt cable connection as necessary, free of charge. The safety recall began on April 30, 2012.
Engine & cooling Vehicle recall #22V119000 · 2022 · 917,106 vehicles
What's wrong: 0si, x3 xdrive30i); 2008-2013 1 series convertible (128i); 2006-2011 3 series sedan (325i, 325xi, 328i, 328xi, 328i xdrive, 330i, 330xi); 2006-2012 3 series wagon (328i, 328i xdrive); 2007-2013 3 series convertible (328i); 2006-2010 5 series sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 series wagon (530xi); 2007-2010 x5 sav (x5 3.0si, x5 xdrive30i); 2006-2008 z4 coupe (z4 3.0si); and 2006-2011 z4…
Why it matters: An electrical short can cause the pcv valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
The fix: This recall supersedes and expands previous NHTSA recalls 17v-683 and 19v-273. Dealers will install an electrical wiring harness with fuse protection for the pcv valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17v-683 and…
1 aftermarket equipment / tire recall replacement parts sold to fit this car, not the car itself
Engine & cooling Equipment recall #12E029000 · 2012 · 585 vehicles
What's wrong: This recall involves aftermarket parts sold by valeo. Valeo is recalling certain engine cooling fans, part numbers 696121, 696273, and 696275, used as service replacement parts for model year 2008-2011 BMW 1-series, 2006-2011 BMW 3-series, 2000-2009 BMW 5-series, 2004-2005 BMW 6-series, and 2006-2007 BMW 7-series vehicles. A metal-oxide semiconductor May overheat due to insufficient screwing of the semiconductor on…
Why it matters: This condition could cause the fan motor to become inoperative, or cause the motor circuit board in the assembly to overheat, potentially leading to a fire in the engine compartment.
The fix: Valeo will notify owners and replace the fans free of charge. The safety recall began on August 22, 2012. This recall is being conducted by valeo, not by BMW. For further information,
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 0 mention a fire, 0 injuries and 0 deaths were reported.
What owners describe
- Electrical (2): no single recurring theme in the descriptions.
- Engine (2): no single recurring theme in the descriptions.
- Fuel system (2): no single recurring theme in the descriptions.
- Fuel & propulsion (2): no single recurring theme in the descriptions.
The 2009 BMW 5 Series has 8 owner complaints, ranking #9 of 18 5 Series model years for complaints (well below the 24 average). Complaints peaked in 2016 (3 filed that year). The typical problem showed up when the car was about 5 years old, at a median of 59,500 miles. Neighboring years: 2008 (105 complaints, 3 recalls), 2010 (6 complaints, 5 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 3.0 L 6-cyl | Manual 6-spd | Rear-Wheel Drive | 18 | 28 | 21 | Premium |
| 3.0 L 6-cyl | Automatic (S6) | Rear-Wheel Drive | 18 | 27 | 21 | Premium |
| 3.0 L 6-cyl | Manual 6-spd | 4-Wheel or All-Wheel Drive | 17 | 25 | 20 | Premium |
| 3.0 L 6-cyl | Automatic (S6) | 4-Wheel or All-Wheel Drive | 17 | 25 | 20 | Premium |
| 3.0 L 6-cyl turbo | Manual 6-spd | Rear-Wheel Drive | 17 | 26 | 20 | Premium |
| 3.0 L 6-cyl turbo | Automatic (S6) | Rear-Wheel Drive | 17 | 26 | 20 | Premium |
| 3.0 L 6-cyl turbo | Manual 6-spd | 4-Wheel or All-Wheel Drive | 16 | 25 | 19 | Premium |
| 3.0 L 6-cyl turbo | Automatic (S6) | 4-Wheel or All-Wheel Drive | 16 | 24 | 19 | Premium |
| 4.8 L 8-cyl | Manual 6-spd | Rear-Wheel Drive | 15 | 22 | 18 | Premium |
| 4.8 L 8-cyl | Automatic (S6) | Rear-Wheel Drive | 15 | 23 | 18 | Premium |
| 3.0 L 6-cyl turbo | Manual 6-spd | 4-Wheel or All-Wheel Drive | 16 | 23 | 18 | Premium |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2009 BMW 5 Series.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2009 BMW 5 Series have any recalls?
Yes. NHTSA lists 3 vehicle recalls for the 2009 BMW 5 Series, plus 1 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2009 BMW 5 Series problems?
Owners have filed 8 complaints with NHTSA. The most-reported areas are electrical (2), engine (2), fuel system (2).
What gas mileage does the 2009 BMW 5 Series get?
EPA ratings run up to 21 mpg combined (3.0 L, Manual 6-spd), across 11 engine and transmission combos.
Where can I get a 2009 BMW 5 Series repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.