2007 Chevrolet Cobalt: Recalls, Problems & MPG
Here are the deets on the 2007 Chevrolet Cobalt: 5 recalls, 1564 owner complaints and up to 25 mpg combined.
Recalls
5 vehicle recalls from the manufacturer, plus 1 equipment/tire recall that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Fuel system Vehicle recall #09V419000 · 2009 · 69,139 vehicles
What's wrong: The plastic supply or return port on the modular reservoir assembly May crack. If either of these ports develops a crack, fuel will leak from the area. If the crack becomes large enough, fuel May be observed dripping onto the ground and vehicle performance May be affected.
Why it matters: Fuel leakage, in the presence of an ignition source, could result in a fire.
The fix: Dealers will replace the fuel pump module free of charge. A special coverage will be implemented in the same time frame for model year 2006 vehicles registered in alabama, arkansas, california, florida, georgia, hawaii, louisiana, mississippi, north carolina, new mexico, oklahoma, south carolina,…
Steering Vehicle recall #10V073000 · 2010 · 1,050,889 vehicles
What's wrong: The driver May experience a sudden loss of power steering assist that could occur at any time while driving.
Why it matters: If power steering assist is lost, it would require greater driver effort at low vehicle speeds, increasing the risk of a crash.
The fix: Dealers will replace the electric power steering motor free of charge. Owners are being notified on a rolling basis between March 29 through November 2010. A copy of the mailing schedule is located in the recall file.
Fuel system Vehicle recall #12V459000 · 2012 · 49,768 vehicles
What's wrong: Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module May crack, which could cause a fuel leak.
Why it matters: Fuel leakage in the presence of an ignition source May result in a fire.
The fix: Gm will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013.
Airbags, Electrical Vehicle recall #14V047000 · 2014 · 2,190,934 vehicles
What's wrong: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General motors LLC (gm) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet cobalt, and 2007 Pontiac g5 vehicles.…
Why it matters: If the key is not in the run position, the air bags May not deploy if the vehicle is involved in a crash, increasing the risk of injury.
The fix: Gm will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014.…
Electrical Vehicle recall #14V171000 · 2014 · 2,191,014 vehicles
What's wrong: In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "off" position.
Why it matters: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission…
The fix: General motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for…
1 aftermarket equipment / tire recall replacement parts sold to fit this car, not the car itself
Electrical Equipment recall #14E021000 · 2014 · 14,529 vehicles
What's wrong: The weight on the key ring and/or road conditions or some other jarring event May cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.
Why it matters: If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.
The fix: Uci-fram group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by gm dealers as part of NHTSA recall 14v-047, free of charge. Uci-fram's purchasers should contact uci-fram group at 1-800-890-2075. Gm vehicle owners…
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 16 mention a fire, 109 injuries and 7 deaths were reported.
What owners describe
- Steering (689): the most common themes are steering problems (657), warning light on (152).
- Fuel & propulsion (283): the most common themes are leaks (194), fire / smoke (32), rust / corrosion (30).
- Electrical (281): the most common themes are electrical failure (107), stalls / loses power (66).
- Fuel system (150): the most common themes are leaks (86), fire / smoke (17).
The 2007 Chevrolet Cobalt has 1564 owner complaints, ranking #3 of 13 Cobalt model years for complaints (2.6× the average Cobalt year). Complaints peaked in 2010 (333 filed that year). The typical problem showed up when the car was about 5 years old, at a median of 64,117 miles. Neighboring years: 2006 (2330 complaints, 5 recalls), 2008 (845 complaints, 4 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 2.4 L 4-cyl | Manual 5-spd | Front-Wheel Drive | 22 | 31 | 25 | Premium |
| 2.2 L 4-cyl | Manual 5-spd | Front-Wheel Drive | 22 | 31 | 25 | Regular |
| 2.4 L 4-cyl | Automatic 4-spd | Front-Wheel Drive | 21 | 29 | 24 | Premium |
| 2.2 L 4-cyl | Automatic 4-spd | Front-Wheel Drive | 21 | 29 | 24 | Regular |
| 2.0 L 4-cyl | Manual 5-spd | Front-Wheel Drive | 20 | 28 | 23 | Premium |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2007 Chevrolet Cobalt.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2007 Chevrolet Cobalt have any recalls?
Yes. NHTSA lists 5 vehicle recalls for the 2007 Chevrolet Cobalt, plus 1 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2007 Chevrolet Cobalt problems?
Owners have filed 1564 complaints with NHTSA. The most-reported areas are steering (689), fuel & propulsion (283), electrical (281).
What gas mileage does the 2007 Chevrolet Cobalt get?
EPA ratings run up to 25 mpg combined (2.4 L, Manual 5-spd), across 5 engine and transmission combos.
Where can I get a 2007 Chevrolet Cobalt repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.