2008 Chevrolet Hhr: Recalls, Problems & MPG
Here are the deets on the 2008 Chevrolet Hhr: 4 recalls, 616 owner complaints and up to 25 mpg combined.
Recalls
4 vehicle recalls from the manufacturer, plus 1 equipment/tire recall that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Airbags Vehicle recall #08V046000 · 2008 · 181,516 vehicles
What's wrong: 201, 'occupant protection in interior impact.' in tests, one of the upper interior occupant protection test points exceeded the standard's requirement.
Why it matters: This standard specifies performance requirements to provide head impact protection for occupants.
The fix: Dealers will install an energy-absorbing plastic piece to the headliner trim. The recall began on April 2, 2008.
Latches & locks Vehicle recall #08V444000 · 2008 · 296,422 vehicles
What's wrong: 201, 'occupant protection in interior impact." the door on the storage bin in the top center of the instrument panel failed to remain closed as required.
Why it matters: This standard specifies performance requirements to provide head impact protection for occupants.
The fix: A redesigned latch will be made available. The recall began on December 23, 2008.
Airbags, Electrical Vehicle recall #14V047000 · 2014 · 2,190,934 vehicles
What's wrong: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General motors LLC (gm) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet cobalt, and 2007 Pontiac g5 vehicles.…
Why it matters: If the key is not in the run position, the air bags May not deploy if the vehicle is involved in a crash, increasing the risk of injury.
The fix: Gm will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014.…
Electrical Vehicle recall #14V171000 · 2014 · 2,191,014 vehicles
What's wrong: In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "off" position.
Why it matters: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission…
The fix: General motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for…
1 aftermarket equipment / tire recall replacement parts sold to fit this car, not the car itself
Electrical Equipment recall #14E021000 · 2014 · 14,529 vehicles
What's wrong: The weight on the key ring and/or road conditions or some other jarring event May cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.
Why it matters: If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.
The fix: Uci-fram group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by gm dealers as part of NHTSA recall 14v-047, free of charge. Uci-fram's purchasers should contact uci-fram group at 1-800-890-2075. Gm vehicle owners…
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 6 mention a fire, 31 injuries and 4 deaths were reported.
What owners describe
- Steering (297): the most common themes are steering problems (288), warning light on (58).
- Electrical (108): the most common themes are electrical failure (43), door / lock issues (27).
- Fuel & propulsion (71): the most common themes are leaks (57), rust / corrosion (43).
- Brakes (hydraulic) (40): the most common themes are brake failure / soft pedal (11), noise or vibration (7).
The 2008 Chevrolet Hhr has 616 owner complaints, ranking #3 of 6 Hhr model years for complaints (about average; the typical year has 596). Complaints peaked in 2014 (179 filed that year). The typical problem showed up when the car was about 6 years old, at a median of 75,402 miles. Neighboring years: 2007 (726 complaints, 4 recalls), 2009 (508 complaints, 4 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 2.2 L 4-cyl | Automatic 4-spd | Front-Wheel Drive | 22 | 30 | 25 | Regular |
| 2.2 L 4-cyl | Manual 5-spd | Front-Wheel Drive | 21 | 30 | 24 | Regular |
| 2.4 L 4-cyl | Automatic 4-spd | Front-Wheel Drive | 22 | 28 | 24 | Premium |
| 2.0 L 4-cyl turbo | Manual 5-spd | Front-Wheel Drive | 21 | 29 | 24 | Regular |
| 2.4 L 4-cyl | Manual 5-spd | Front-Wheel Drive | 20 | 28 | 23 | Premium |
| 2.0 L 4-cyl turbo | Automatic 4-spd | Front-Wheel Drive | 19 | 28 | 22 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2008 Chevrolet Hhr.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2008 Chevrolet Hhr have any recalls?
Yes. NHTSA lists 4 vehicle recalls for the 2008 Chevrolet Hhr, plus 1 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2008 Chevrolet Hhr problems?
Owners have filed 616 complaints with NHTSA. The most-reported areas are steering (297), electrical (108), fuel & propulsion (71).
What gas mileage does the 2008 Chevrolet Hhr get?
EPA ratings run up to 25 mpg combined (2.2 L, Automatic 4-spd), across 6 engine and transmission combos.
Where can I get a 2008 Chevrolet Hhr repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.