2000 Chevrolet Malibu: Recalls, Problems & MPG
Here are the deets on the 2000 Chevrolet Malibu: 3 recalls, 922 owner complaints and up to 23 mpg combined.
Recalls
3 vehicle recalls from the manufacturer, plus 2 equipment/tire recalls that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Fuel system Vehicle recall #99V302000 · 1999 · 43,218 vehicles
What's wrong: Certain passenger vehicles fail to comply with requirements of fmvss no. 301, "fuel system integrity." the fuel fill fitting is not properly secured to the fuel tank. In that condition, fuel leakage would exceed the permissible amount in an fmvss test. Fuel leaks May occur, particularly after refueling or when the tank is more than half full.
Why it matters: If an ignition source were present, a fire could occur.
The fix: Dealers will inspect the fuel tank and replace it if necessary.
Exterior lights Vehicle recall #03V327000 · 2003 · 670,740 vehicles
What's wrong: Certain passenger vehicles have hazard warning switches that May experience solder joint cracking caused by rapid temperature transitions and the soldering process. If solder joint cracking occurs and results in an open circuit, the turn signals/hazard lamps become intermittent or inoperative.
Why it matters: When the turn signals are inoperative, the driver cannot use them to signal intent to turn that could result in a crash.
The fix: Dealers will replace the hazard warning switch. Owner notification began on February 5, 2004. Owners should contact Chevrolet at 1-800-630-2438, Pontiac at 1-800-620-7668, or Oldsmobile at 1-800-630-6537.
Electrical Vehicle recall #14V400000 · 2014 · 5,877,718 vehicles
What's wrong: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General motors LLC (gm) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet impala and monte carlo, 1997-2003…
Why it matters: If the key is not in the run position, the air bags May not deploy if the vehicle is involved in a crash, increasing the risk of injury.
The fix: Gm will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. Gm's number for this recall is 14350.
2 aftermarket equipment / tire recalls replacement parts sold to fit this car, not the car itself
Fuel system (other) Equipment recall #07E021000 · 2007 · 742 vehicles
What's wrong: Certain delphi fuel pressure regulators, p/nos. Fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after January 9, 2007, as aftermarket equipment for various passenger vehicles listed above. The universal pressure regulators (upr) were produced without an o'ring and retainer.
Why it matters: Fuel May leak, possibly resulting in a fire.
The fix: Delphi will notify owners and replace the upr free of charge. The recall began on April 23, 2007. Owners can contact delphi at 877-411-8770.
Exterior lights Equipment recall #09E012000 · 2009 · 16,270 vehicles
What's wrong: These headlamps fail to conform to the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Why it matters: Decreased lighting visibility May result in a vehicle crash.
The fix: Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on May 11, 2009.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 6 mention a fire, 36 injuries and 3 deaths were reported.
What owners describe
- Exterior lights (241): the most common themes are warning light on (39), electrical failure (19), noise or vibration (14).
- Brakes (hydraulic) (228): the most common themes are noise or vibration (76), brake failure / soft pedal (22).
- Electrical (199): the most common themes are electrical failure (57), stalls / loses power (43), won't start (26).
- Engine & cooling (174): the most common themes are leaks (69), stalls / loses power (43), noise or vibration (32).
The 2000 Chevrolet Malibu has 922 owner complaints, ranking #10 of 29 Malibu model years for complaints (about average; the typical year has 667). Complaints peaked in 2004 (161 filed that year). The typical problem showed up when the car was about 4 years old, at a median of 69,000 miles. Neighboring years: 1999 (789 complaints, 1 recalls), 2001 (721 complaints, 2 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 2.4 L 4-cyl | Automatic 4-spd | Front-Wheel Drive | 19 | 28 | 23 | Regular |
| 3.1 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 18 | 27 | 21 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2000 Chevrolet Malibu.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2000 Chevrolet Malibu have any recalls?
Yes. NHTSA lists 3 vehicle recalls for the 2000 Chevrolet Malibu, plus 2 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2000 Chevrolet Malibu problems?
Owners have filed 922 complaints with NHTSA. The most-reported areas are exterior lights (241), brakes (hydraulic) (228), electrical (199).
What gas mileage does the 2000 Chevrolet Malibu get?
EPA ratings run up to 23 mpg combined (2.4 L, Automatic 4-spd), across 2 engine and transmission combos.
Where can I get a 2000 Chevrolet Malibu repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.