2002 Chevrolet Trailblazer Ext: Recalls, Problems & MPG
Here are the deets on the 2002 Chevrolet Trailblazer Ext: 3 recalls, 100 owner complaints and up to 16 mpg combined.
Recalls
3 vehicle recalls from the manufacturer. Repairs are free. Check your VIN to see if one is still open on your car.
Visibility (wipers, glass) Vehicle recall #04V046000 · 2004 · 581,394 vehicles
What's wrong: Certain sport utility vehicles have windshield wiper systems that will not turn on, cease operation while in use, fail to turn off/on by themselves (moisture sensitive wiper system), or have continuous windshield washer pump operation because the presence of water within the wiper modules can either cause a short circuit or can lead to the corrosion of components within the module.
Why it matters: Depending on the occurrence and weather situation, driver visibility could be reduced, which could result in a crash.
The fix: Dealers will cover the windshield wiper module vent hole with a patch. Also, the wiper motor, circuit board, and electrical connector will be inspected to signs of water intrusion and/or corrosion and be replaced as required. The recall began July 6, 2004. Owners should contact Chevrolet at…
Exterior lights Vehicle recall #04V527000 · 2004 · 871,473 vehicles
What's wrong: On certain sport utility vehicles, vibration and heat May cause the tail lamp/stop lamp bulb to loosen in its socket. If this occurs, the bulb May flicker and eventually become inoperative.
Why it matters: An inoperative brake lamp will not convey the driver's intention of stopping to drivers in following vehicles, and an inoperative rear turn signal lamp will not convey the driver's intention to turn to drivers in following vehicles. Both of these failures can increase the risk of a crash.
The fix: Dealers will inspect the tail lamp/stop lamp assemblies, and if necessary, replace them. The recall began on November 22, 2004. Owners should contact Chevrolet at 1-800-630-2438, Oldsmobile at 1-800-630-6537, Buick at 1-866-608-8080, or GMC at 1-866-996-9463.
Latches & locks Vehicle recall #05V494000 · 2005 · 98,007 vehicles
What's wrong: Certain sport utility vehicles have a rear side closure latch that May not latch or unlatch due to corrosion caused by road splash, such as water and road salt. These vehicles were originally sold in or currently registered in the following states: connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania,…
Why it matters: If the door is not latched properly and it goes unnoticed, it May open while the vehicle is in motion. If an unbelted occupant fell out of the vehicle, personal injuries could occur.
The fix: Dealers will install a seal along the lower part of the rocker panel to prevent intrusion of corrosive material, and inspect the rear side closure latches. Functional latches will be cleaned and lubricated. Non-functioning latches will be replaced. The recall began on February 24, 2006.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 2 mention a fire, 1 injuries and 0 deaths were reported.
What owners describe
- Fuel system (23): the most common themes are leaks (12), warning light on (8), fire / smoke (4).
- Transmission & drivetrain (20): the most common themes are noise or vibration (9), hard / delayed shifting (5).
- Electrical (14): the most common themes are electrical failure (7), leaks (3), stalls / loses power (3).
- Engine & cooling (14): the most common themes are noise or vibration (3).
The 2002 Chevrolet Trailblazer Ext has 100 owner complaints, ranking #4 of 4 Trailblazer Ext model years for complaints (well below the 216 average). Complaints peaked in 2007 (19 filed that year). The typical problem showed up when the car was about 5 years old, at a median of 64,000 miles. Neighboring years: 2003 (313 complaints, 3 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 4.2 L 6-cyl | Automatic 4-spd | Rear-Wheel Drive | 14 | 19 | 16 | Regular |
| 4.2 L 6-cyl | Automatic 4-spd | 4-Wheel or All-Wheel Drive | 14 | 19 | 15 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2002 Chevrolet Trailblazer Ext.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2002 Chevrolet Trailblazer Ext have any recalls?
Yes. NHTSA lists 3 vehicle recalls for the 2002 Chevrolet Trailblazer Ext. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2002 Chevrolet Trailblazer Ext problems?
Owners have filed 100 complaints with NHTSA. The most-reported areas are fuel system (23), transmission & drivetrain (20), electrical (14).
What gas mileage does the 2002 Chevrolet Trailblazer Ext get?
EPA ratings run up to 16 mpg combined (4.2 L, Automatic 4-spd), across 2 engine and transmission combos.
Where can I get a 2002 Chevrolet Trailblazer Ext repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.