2000 Chevrolet Venture: Recalls, Problems & MPG
Here are the deets on the 2000 Chevrolet Venture: 5 recalls, 350 owner complaints and up to 19 mpg combined.
Recalls
5 vehicle recalls from the manufacturer, plus 3 equipment/tire recalls that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Fuel system Vehicle recall #99V268000 · 1999 · 235 vehicles
What's wrong: Some of these vehicles have inoperative fuel tank rollover valves and fuel leakage would exceed the permissible amount in a rollover test. This does not comply with the requirements of fmvss no. 301, "fuel system integrity."
Why it matters: In a vehicle rollover accident, if an ignition source is present, a fire could result.
The fix: Dealers will inspect the vehicles to locate and replace those fuel tanks that could have inoperative rollover valves.
Seat belts Vehicle recall #00V228003 · 2000 · 156,305 vehicles
What's wrong: The buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of Federal Motor Vehicle Safety Standard no. 209, "seat belt assemblies."
Why it matters: In the event of a vehicle crash, the occupant May not be properly restrained.
The fix: Dealers will inspect the vehicle's safety belt buckle assembly date codes and, if necessary, will replace any safety belt buckle assembly.
Latches & locks Vehicle recall #01V067000 · 2001 · 477,011 vehicles
What's wrong: The door closes but May not be latched. If this happens, the power sliding door can open while the vehicle is in motion, particularly when the vehicle ascends a hill, makes a turn, or travels over a rough road surface.
Why it matters: An unrestrained occupant could fall out of the van and be injured.
The fix: Dealers will install a new un-latch actuator assembly to the power sliding door. This recall has been continued under safety recall 01v-264.
Latches & locks Vehicle recall #01V264000 · 2001 · 248,737 vehicles
What's wrong: Also 2001 Chevrolet venture, Pontiac montana, and Oldsmobile silhouette MINI vans equipped with passenger side power sliding doors assembled in January through April 2001. These vehicles have inadequate front welds. If a front weld fails, the actuator can jam in the unlatched position and, when the sliding door closes, it will not be latched.
Why it matters: If this happens, the power sliding door can open while the vehicle is in motion, particularly when the vehicle ascends a hill, makes a turn, or travels over a rough road surface. An unrestrained occupant could fall out of the van and be injured.
The fix: Dealers will inspect and, if required, install a new power sliding door unlatch actuator assembly. Owner notification began on October 22, 2001.
Latches & locks Vehicle recall #04V597000 · 2004 · 717,302 vehicles
What's wrong: On certain minivans equipped with second-row bucket seats or captain's chairs and a power sliding door on the passenger side of the vehicle, a passenger using the interior handle to open the power sliding door could be injured.
Why it matters: If a passenger uses the interior handle to open the power sliding door and holds onto the handle while it is being opened by the motor, the passenger's arm May be pushed into the seat back or armrest and a wrist or lower arm injury May result.
The fix: Dealers will replace the power sliding door interior handle on the passenger-side. If the vehicle is equipped with a power or manual sliding door on the driver-side, the interior handle will also be replaced for appearance reasons.
3 aftermarket equipment / tire recalls replacement parts sold to fit this car, not the car itself
Fuel system (other) Equipment recall #07E021000 · 2007 · 742 vehicles
What's wrong: Certain delphi fuel pressure regulators, p/nos. Fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after January 9, 2007, as aftermarket equipment for various passenger vehicles listed above. The universal pressure regulators (upr) were produced without an o'ring and retainer.
Why it matters: Fuel May leak, possibly resulting in a fire.
The fix: Delphi will notify owners and replace the upr free of charge. The recall began on April 23, 2007. Owners can contact delphi at 877-411-8770.
Exterior lights Equipment recall #08E050000 · 2008 · 1,921 vehicles
What's wrong: These headlamps are missing the amber side reflex reflector which fails to conform with the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment."
Why it matters: Without the amber side reflex reflectors, the lighting visibility May be affected, possibly resulting in a vehicle crash.
The fix: K2 motor will notify owners and offer a full refund. The recall began on decemeber 17, 2008.
Steering Equipment recall #09E005000 · 2009 · 979 vehicles
What's wrong: 697-902 and 697-903, sold under dorman's "oe solutionstm" brand name, and napa p/nos. 7-8502 and 7-8503 which were sold for replacement use on the various vehicles listed above. A potential material or design defect could result in the steering knuckle breaking in the hub area.
Why it matters: A broken steering knuckle could result in loss of steering control and a possible crash without warning.
The fix: Dorman will notify owners and replace the defective steering knuckles free of charge and reimburse the repair facility or owner for labor. The recall began on February 23, 2009.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 5 mention a fire, 42 injuries and 0 deaths were reported.
What owners describe
- Engine & cooling (82): the most common themes are leaks (47), warning light on (10), electrical failure (6).
- Body & structure (50): the most common themes are door / lock issues (41), rust / corrosion (7), noise or vibration (3).
- Electrical (44): the most common themes are electrical failure (23), stalls / loses power (10), fire / smoke (6).
- Airbags (31): the most common themes are fails to deploy (10), warning light on (4).
The 2000 Chevrolet Venture has 350 owner complaints, ranking #3 of 10 Venture model years for complaints (about average; the typical year has 234). Complaints peaked in 2004 (60 filed that year). The typical problem showed up when the car was about 3 years old, at a median of 65,000 miles. Neighboring years: 1999 (349 complaints, 4 recalls), 2001 (222 complaints, 9 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 3.4 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 17 | 24 | 19 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2000 Chevrolet Venture.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2000 Chevrolet Venture have any recalls?
Yes. NHTSA lists 5 vehicle recalls for the 2000 Chevrolet Venture, plus 3 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2000 Chevrolet Venture problems?
Owners have filed 350 complaints with NHTSA. The most-reported areas are engine & cooling (82), body & structure (50), electrical (44).
What gas mileage does the 2000 Chevrolet Venture get?
EPA ratings run up to 19 mpg combined (3.4 L, Automatic 4-spd), across 1 engine and transmission combos.
Where can I get a 2000 Chevrolet Venture repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.