2005 Chrysler Town And Country: Recalls, Problems & MPG
Here are the deets on the 2005 Chrysler Town And Country: 4 recalls, 857 owner complaints and up to 19 mpg combined.
Recalls
4 vehicle recalls from the manufacturer, plus 3 equipment/tire recalls that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Seat belts Vehicle recall #04V047000 · 2004 · 3,200 vehicles
What's wrong: After performing the ncap test, it was discovered that on certain minivans equipped without the available "stow 'n go" seating option, the right front seat belt retractor assembly May have been improperly assembled.
Why it matters: As a result, the seat belt May not properly restrain the occupant during certain crash conditions, which can increase the risk of injury.
The fix: Dealers will inspect the retractor assemblies and any seat belt assembly that does not have the stake will be replaced. Owner notification began on February 23, 2004. Owners should contact daimlerchrysler at 1-800-853-1403.
Visibility (wipers, glass) Vehicle recall #06V067000 · 2006 · 268,800 vehicles
What's wrong: On certain vans and sport utility vehicles, the front windshield wiper motor armature shaft May break.
Why it matters: During certain operating conditions, loss of front windshield wiping capability could occur, and the driver's vision could be obscured which could result in a crash.
The fix: Dealers will inspect and replace the windshield wiper motor free of charge. The recall began on June 19, 2006, to Dodge durango owners. Minivan owners will be notified during July 2006.
Airbags Vehicle recall #07V192000 · 2007 · 270,958 vehicles
What's wrong: Certain minivans are being recalled that were originally sold in or currently registered in the 27 states plus the district of columbia that use greater amounts of salt for winter road deicing. The up-front (uf) air bag sensors that contain brass bushings installed in these vehicles May corrode and crack allowing water to enter the sensor. These sensors provide enhanced air bag performance in certain types of…
Why it matters: In one of these crashes, with one or both of the vehicle's uf sensors inoperative, the occupants will not benefit from the enhanced air bag protection that these sensors would provide.
The fix: For vehicles registered in the recall states, dealers will replace the original uf air bag sensors with ones with greater corrosion resistance. Vehicles registered in other states will obtain a lifetime free replacement of any uf sensor that fails. The campaign began on July 2, 2007.
Airbags Vehicle recall #10V008000 · 2010 · 308,950 vehicles
What's wrong: The front crash sensors May crack under certain environmental conditions and allow water to enter into the sensor. This can cause the sensor to become inoperative and illuminate the airbag warning light. These sensors were added to enhance the performance of the airbag system in certain frontal crashes.
Why it matters: If the front crash sensors become inoperative, the driver is immediately alerted by illumination of the airbag warning light and the vehicle should be promptly serviced. Until the vehicle is repaired, the airbags May not provide the enhanced protection in the event of a crash.
The fix: Chrysler will replace the front airbag sensors with a new design. This service will be performed free of charge. The safety improvement campaign will begin during June 2010.
3 aftermarket equipment / tire recalls replacement parts sold to fit this car, not the car itself
Brakes (hydraulic) Equipment recall #06E022000 · 2006 · 7,440 vehicles
What's wrong: Certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain Ford, daimlerchrysler, and Jeep passenger vehicles. These brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. Only products that were manufactured from July 27, 2005 through January 17, 2006 (date codes 0529 through 0602) are subject to this recall. When…
Why it matters: Loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.
The fix: Affinia (brake parts, Inc.) will replace the subject brake hydraulic master cylinders free of charge. The recall began on March 20, 2006. Owners can contact affina group customer service at 1-800-323-0354.
Visibility (wipers, glass) Equipment recall #07E104000 · 2007 · 1,657 vehicles
What's wrong: Certain curved tempered replacement glass manufactured by hangzhou safety glass Ltd and supplied to safelite by auto temp Inc., identified as dot-430, and sold for use on certain domestic and foreign vehicles May not break into small pieces as expected of tempered glass and fails to conform to Federal Motor Vehicle Safety Standard no. 205, "glazing materials."
Why it matters: In the event of a vehicle crash, the occupant(s) May be seriously injured by shattered glass.
The fix: Safelite will notify its retail customers and replace the glass free of charge. Retail customers can contact safelite toll free at 1-888-843-2906. Safelite will notify its wholesale customers and reimburse wholesale customers for current inventory and at a specified rate for replacing their…
Equipment Equipment recall #10E034000 · 2010 · 6,686 vehicles
What's wrong: When the hitch is loaded to the maximum rating, the hitch May fracture or break at the bend location where the main body of the hitch meets the hitch muffler strap.
Why it matters: If the area in question fractures or breaks, this could cause an unstable driving condition, possibly resulting in a crash.
The fix: Curt mfg will notify owners of record and will replace the hitch free of charge. The safety recall is expected to begin during August 2010.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 14 mention a fire, 55 injuries and 0 deaths were reported.
What owners describe
- Electrical (164): the most common themes are electrical failure (68), door / lock issues (53), stalls / loses power (38).
- Airbags (153): the most common themes are warning light on (65), fails to deploy (19).
- Steering (121): the most common themes are steering problems (99), noise or vibration (57), leaks (40).
- Exterior lights (116): the most common themes are stalls / loses power (17), warning light on (12), electrical failure (10).
The 2005 Chrysler Town And Country has 857 owner complaints, ranking #4 of 29 Town And Country model years for complaints (1.8× the average Town And Country year). Complaints peaked in 2010 (105 filed that year). The typical problem showed up when the car was about 5 years old, at a median of 65,000 miles. Neighboring years: 2004 (167 complaints, 1 recalls), 2006 (431 complaints, 2 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 3.3 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 17 | 24 | 19 | Regular |
| 3.3 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 16 | 23 | 19 | Gasoline or E85 |
| 3.8 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 16 | 23 | 18 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2005 Chrysler Town And Country.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2005 Chrysler Town And Country have any recalls?
Yes. NHTSA lists 4 vehicle recalls for the 2005 Chrysler Town And Country, plus 3 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2005 Chrysler Town And Country problems?
Owners have filed 857 complaints with NHTSA. The most-reported areas are electrical (164), airbags (153), steering (121).
What gas mileage does the 2005 Chrysler Town And Country get?
EPA ratings run up to 19 mpg combined (3.3 L, Automatic 4-spd), across 3 engine and transmission combos.
Where can I get a 2005 Chrysler Town And Country repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.