2002 Dodge Dakota: Recalls, Problems & MPG
Here are the deets on the 2002 Dodge Dakota: 5 recalls, 678 owner complaints and up to 19 mpg combined.
Recalls
5 vehicle recalls from the manufacturer, plus 7 equipment/tire recalls that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Electrical Vehicle recall #03V389000 · 2003 · 50,082 vehicles
What's wrong: On certain pickup trucks equipped with manual transmissions, the headlamp and dash wiring harness May be chafed by the actuation of the clutch pedal. This could result in abnormal operation of the wipers, turn signals, horn or lighting systems.
Why it matters: This could affect driver visibility, could prevent a driver from sounding a warning by using the horn, and, when the turn signals are inoperative, the driver cannot use them to signal intent to turn, increasing the risk of a crash.
The fix: Dealers will reroute the wire harness and repair the harness if necessary. Owner notification began November 3, 2003. Owners should contact daimlerchrysler at 1-800-992-1997.
Equipment Vehicle recall #03V505000 · 2003 · 35,692 vehicles
What's wrong: On certain minivans and 4x2 pickup trucks, the vehicle certification label May have gross axle weight ratings (gawr) that exceed the maximum tire load capacity as defined in Federal Motor Vehicle Safety Standard no. 120, "tire selection and rims for motor vehicles other than passenger cars."
Why it matters: Improperly loading your vehicle can cause tire failure and result in a crash.
The fix: Owners will be provided with vehicle certification label overlays containing corrected information relative to vehicle gawr and tire size. Owner notification began March 1, 2004. Owners should contact daimlerchrysler at 1-800-992-1997.
Visibility (wipers, glass) Vehicle recall #04V216000 · 2004 · 320,188 vehicles
What's wrong: On certain pickup trucks and sport utility vehicles, the windshield wiper module motor May be susceptible to water intrusion that could cause internal corrosion and result in partial or complete loss of front windshield wiping capability.
Why it matters: Driver visibility could be reduced, which could result in a crash.
The fix: Dealers will replace the front windshield wiper module. Owner notification began on July 12, 2004. Owners should contact daimlerchrysler at 1-800-853-1403.
Suspension Vehicle recall #04V596000 · 2004 · 592,707 vehicles
What's wrong: On certain sport utility vehicles and pickup trucks equipped with four-wheel drive (4x4), if moisture leaks into the front suspension upper ball joint, evacuation of the lubricant and corrosion of the joint May cause the joint to wear over an extended period of time. This could cause a clunking noise in the front suspension, which May not always be heard by the vehicle occupants.
Why it matters: Excessive wear in the upper ball joint May allow it to separate, which could result in loss of control of the vehicle.
The fix: Dealers will replace the front suspension upper ball joints. This safety improvement campaign began on December 21, 2004. Owners can contact daimlerchrysler at 1-800-853-1403.
Transmission & drivetrain Vehicle recall #07V555000 · 2007 · 576,418 vehicles
What's wrong: On certain van and pickup trucks equipped with automatic transmissions, the ignition/park shift interlock system May become inoperative. This can allow the shifter to be moved out of the "park" position with the ignition key removed (or in the "lock" position). This can also allow the ignition key to be removed when the shifter has not been placed in the "park" position.
Why it matters: Either of these conditions could allow the vehicle to roll away causing a crash without warning.
The fix: Dealers will replace the gearshift blocker and bracket assembly free of charge. The recall is expected to begin during January 2008.
7 aftermarket equipment / tire recalls replacement parts sold to fit this car, not the car itself
Fuel system Equipment recall #06E011000 · 2006 · 7,291 vehicles
What's wrong: Certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 Jeep wrangler; 1997-2001 Jeep cherokee; 1997-2004 Jeep grand cherokee; and 2000-2003 Dodge dakota vehicles. The plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and May degrade causing a potential leak path for fuel.
Why it matters: In the presence of an ignition source, a fuel leak could result in a fire.
The fix: Airtex will notify its customers and will replace the affected fuel pumps free of charge. The recall began on January 25, 2006.
Engine & cooling Equipment recall #06E024000 · 2006 · 44,386 vehicles
What's wrong: Certain replacement k&n fuel performance kits, p/nos. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, and 57-1530. Also, a small percentage of these kits were sold under the mopar performance parts brand name (p/nos. P5007069 and p5007070). All kits were manufactured from April 20, 1999, through September 23, 2004. These assemblies were manufactured as replacement equipment for certain Dodge pickup trucks…
Why it matters: A jammed open throttle could cause unintended acceleration of the vehicle, possibly resulting in a crash or increased stoping distances when braking.
The fix: K&n will provide owners with a free repair kit along with repair instructions. The recall began on April 20, 2006.
Exterior lights Equipment recall #06E026000 · 2006 · 61,944 vehicles
What's wrong: Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
The fix: Pro-a motors will notify owners and offer to repurchase the lamps. The recall began on April 3, 2006.
Exterior lights Equipment recall #06E065000 · 2006 · 3,593 vehicles
What's wrong: Certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and May possibly result in a vehicle crash.
The fix: Aj motorsport will notify owners and offer reimbursement for the lamps. The recall began on July 31, 2006.
Suspension Equipment recall #08E064000 · 2008 · 2,805 vehicles
What's wrong: Br930361, sold as a service part for 1997-2004 Dodge dakota vehicles and 1999-2003 Dodge durango vehicles equipped with 2-wheel drive & rear axle ABS. Due to a specification error, the rotor pilot for the hub unit May be too long. This results in the wheel to not be seated fully against the hub flange face during mounting.
Why it matters: Improper seating of the wheel can result in excessive vibration, brake rotor noise, difficulty removing the wheel after installation and operation of the vehicle, and possibly wheel-end separation during vehicle operation. Should wheel-end separation occur, the driver could loose control of the…
The fix: Skf will notify owners and replace the defective hub units free of charge. The recall began on November 5, 2008.
Exterior lights Equipment recall #09E012000 · 2009 · 16,270 vehicles
What's wrong: These headlamps fail to conform to the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Why it matters: Decreased lighting visibility May result in a vehicle crash.
The fix: Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on May 11, 2009.
Exterior lights Equipment recall #09E025000 · 2009 · 42,540 vehicles
What's wrong: Dope, Inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Why it matters: Decreased lighting visibility May result in a vehicle crash.
The fix: Dope, Inc. will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on July 28, 2009.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 18 mention a fire, 32 injuries and 2 deaths were reported.
What owners describe
- Suspension (226): the most common themes are noise or vibration (106), steering problems (23).
- Brakes (hydraulic) (177): the most common themes are noise or vibration (35), brake failure / soft pedal (24).
- Transmission & drivetrain (89): the most common themes are hard / delayed shifting (47), noise or vibration (16), stalls / loses power (9).
- Electrical (52): the most common themes are electrical failure (12), stalls / loses power (9), door / lock issues (8).
The 2002 Dodge Dakota has 678 owner complaints, ranking #3 of 22 Dakota model years for complaints (2.3× the average Dakota year). Complaints peaked in 2004 (202 filed that year). The typical problem showed up when the car was about 2 years old, at a median of 39,099 miles. Neighboring years: 2001 (678 complaints, 7 recalls), 2003 (296 complaints, 4 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 2.5 L 4-cyl | Manual 5-spd | Rear-Wheel Drive | 17 | 22 | 19 | Regular |
| 3.9 L 6-cyl | Automatic 4-spd | Rear-Wheel Drive | 16 | 18 | 17 | Regular |
| 3.9 L 6-cyl | Manual 5-spd | Rear-Wheel Drive | 14 | 20 | 16 | Regular |
| 4.7 L 8-cyl | Automatic 4-spd | Rear-Wheel Drive | 13 | 18 | 15 | Regular |
| 4.7 L 8-cyl | Manual 5-spd | Rear-Wheel Drive | 13 | 19 | 15 | Regular |
| 3.9 L 6-cyl | Manual 5-spd | 4-Wheel or All-Wheel Drive | 14 | 18 | 15 | Regular |
| 3.9 L 6-cyl | Automatic 4-spd | 4-Wheel or All-Wheel Drive | 13 | 16 | 14 | Regular |
| 4.7 L 8-cyl | Automatic 4-spd | 4-Wheel or All-Wheel Drive | 12 | 16 | 14 | Regular |
| 4.7 L 8-cyl | Manual 5-spd | 4-Wheel or All-Wheel Drive | 13 | 17 | 14 | Regular |
| 5.9 L 8-cyl | Automatic 4-spd | Rear-Wheel Drive | 11 | 15 | 13 | Regular |
| 5.9 L 8-cyl | Automatic 4-spd | 4-Wheel or All-Wheel Drive | 11 | 15 | 12 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2002 Dodge Dakota.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2002 Dodge Dakota have any recalls?
Yes. NHTSA lists 5 vehicle recalls for the 2002 Dodge Dakota, plus 7 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2002 Dodge Dakota problems?
Owners have filed 678 complaints with NHTSA. The most-reported areas are suspension (226), brakes (hydraulic) (177), transmission & drivetrain (89).
What gas mileage does the 2002 Dodge Dakota get?
EPA ratings run up to 19 mpg combined (2.5 L, Manual 5-spd), across 11 engine and transmission combos.
Where can I get a 2002 Dodge Dakota repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.