1999 Ford F-150: Recalls, Problems & MPG
Here are the deets on the 1999 Ford F-150: 7 recalls, 1044 owner complaints and up to 17 mpg combined.
Recalls
7 vehicle recalls from the manufacturer, plus 11 equipment/tire recalls that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Fuel system Vehicle recall #98V194000 · 1998 · 1,700 vehicles
What's wrong: The fuel pressure regulator o-ring May have been damaged when the fuel pressure regulator was installed in the engine fuel rail. If the o-ring is damaged, fuel vapor or leakage could occur.
Why it matters: If an ignition source is present, a fire could result.
The fix: Dealers will replace the fuel pressure regulator.
Speed control / throttle Vehicle recall #98V192000 · 1998 · 1,500 vehicles
What's wrong: A speed control cable May not have fully seated into the accelerator bracket at time of installation. If the cable is not fully seated into this bracket, the cable could separate from the bracket.
Why it matters: A loose cable can result in the throttle not fully returning to idle and cause an increase in stopping distance.
The fix: Dealers will add a retaining clip to the speed control cable fitting at the accelerator bracket.
Equipment Vehicle recall #99V039000 · 1999 · 32,240 vehicles
What's wrong: The tire and rim identification information is incorrect on the certification labels for these vehicles. This does not meet the requirements of fmvss no. 120, "tire selection and rims for motor vehicles other than passenger cars."
Why it matters: If incorrect tire information is given, underrated tires could be placed on the truck causing excessive tire wear or, in extreme cases, possible tire blowouts.
The fix: Owners will be provided with a revised label overlay.
Equipment Vehicle recall #00V284000 · 2000 · 4,500 vehicles
What's wrong: , fail to conform to the requirements of fmvss no. 303, "fuel system integrity of compressed natural gas vehicles." the label affixed to the fuel filler door by the vehicle modifier contains the inspection date and expiration date of the cng tank. However, it does not contain the statement "see instructions on the fuel container for inspection and service life."
Why it matters: These vehicles do not comply with the requirements.
The fix: Owners will be provided a label with the required statement, along with instructions for affixing the label at the fuel filler door. Owner notification began November 2, 2000.
Equipment Vehicle recall #02V008000 · 2002 · 393 vehicles
What's wrong: Certain light duty pickup trucks equipped with a heavy duty service package fail to comply with the requirements of fmvss no. 120, "tire selection and rims for motor vehicles other than passenger cars." a typographical error occurred resulting in an incorrect tire size and pressure on the safety certification label for these vehicles.
Why it matters: If the tires are inflated to the pressure indicated on the label, the customer will experience a harsher ride.
The fix: Owners will be sent a corrected tire information label and installation instructions. The customer May also have the dealer install the label on the vehicle, if they so desire. Owner notification began December 20, 2001. Owners who do not receive the free label and installation instructions within…
Speed control / throttle Vehicle recall #05V388000 · 2005 · 4,500,000 vehicles
What's wrong: On certain pickup trucks and sport utility vehicles equipped with speed control, the speed control deactivation switch May overheat, smoke, or burn.
Why it matters: A fire at the switch could occur.
The fix: By letter dated September 12, 2005, owners were instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. Owners who have had their speed control deactivated are being notified that parts will be available and advised to make an appointment to…
Fuel system Vehicle recall #11V385000 · 2011 · 1,100,000 vehicles
What's wrong: Gross vehicle weight rating (gvwr), and 2002 and 2003 Lincoln blackwood vehicles manufactured from June 20, 1995, through August 4, 2004, originally sold, or currently registered in, connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the…
Why it matters: As a result of the corrosion, one or both straps May fail allowing the fuel lines to separate from the tank, or in some cases, causing the tank to contact the ground. Either scenario May result in a fuel leak presenting a fire hazard.
The fix: Ford will notify owners and instruct them to take their vehicles to a Ford or Lincoln dealer to have the fuel tank straps replaced with straps that have increased corrosion protection. Early in this campaign, if replacement straps are not available, dealers May install a cable support under the…
11 aftermarket equipment / tire recalls replacement parts sold to fit this car, not the car itself
Exterior lights Equipment recall #06E023000 · 2006 · 292,000 vehicles
What's wrong: Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. Some combination lamps are not equipped with amber side reflectors which fail to conform to Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment."
Why it matters: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.
The fix: Anzo will notify owners and replace the headlamps free of charge. The recall began May 9, 2006.
Exterior lights Equipment recall #06E052000 · 2006 · 14,616 vehicles
What's wrong: Certain Eagle eyes headlamps, p/nos. Fr208-b101r, fr208-b101l, fr208-b001r, and fr208-b001l, sold for use as replacement equipment for the passenger vehicles listed above. These headlamps fail to conform to the photometric requirements of Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: Decreased lighting visibility May result in a vehicle crash.
The fix: Sabry lee will notify owners and offer full credit for any noncompliant headlamp. The recall is expected to begin on June 14, 2006.
Fuel system Equipment recall #06E056000 · 2006 · 58,640 vehicles
What's wrong: Certain aftermarket fuel filters sold under the purolator brand name, p/n f65277, shipped from January 16 through June 2, 2006, for use on the above listed passenger vehicles. Due to incorrect design, the quick connectors May not fully seat with the tube interface, even though the person making the connection May believe that the quick connector is fully attached.
Why it matters: Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.
The fix: Ufi will notify owners and replace the filters free of charge. The recall began on August 4, 2006.
Exterior lights Equipment recall #06E060000 · 2006 · 87,745 vehicles
What's wrong: Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment."
Why it matters: Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and May possibly result in a vehicle crash
The fix: Aai motorsports will notify owners and replace the lamps free of charge. The recall began on August 1, 2006.
Exterior lights Equipment recall #06E064000 · 2006 · 4,029 vehicles
What's wrong: Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and May possibly result in a vehicle crash.
The fix: Tradesonic will notify owners and replace the lamps free of charge. The recall is expected to begin during July 2006.
Exterior lights Equipment recall #06E065000 · 2006 · 3,593 vehicles
What's wrong: Certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and May possibly result in a vehicle crash.
The fix: Aj motorsport will notify owners and offer reimbursement for the lamps. The recall began on July 31, 2006.
Exterior lights Equipment recall #06E067000 · 2006 · 19,413 vehicles
What's wrong: Certain maxzone headlight assemblies, depo brand, p/nos. 331-1129l-asn and 331-1129r-asn, sold for use as aftermarket equipment for the above listed passenger vehicles. These headlamps fail to conform to the photometric requirements of Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: Decreased lighting visibility May result in a vehicle crash.
The fix: Maxzone will notify owners and offer reimbursement for any noncompliant headlights. The recall began on July 28, 2006.
Equipment Equipment recall #07E066000 · 2007 · 175 vehicles
What's wrong: Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. Due to incorrect wiring of the harness, the trailer lights May not operate properly.
Why it matters: If the trailer lights are not working properly, a vehicle crash can occur.
The fix: All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
Exterior lights Equipment recall #08E050000 · 2008 · 1,921 vehicles
What's wrong: These headlamps are missing the amber side reflex reflector which fails to conform with the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment."
Why it matters: Without the amber side reflex reflectors, the lighting visibility May be affected, possibly resulting in a vehicle crash.
The fix: K2 motor will notify owners and offer a full refund. The recall began on decemeber 17, 2008.
Exterior lights Equipment recall #09E012000 · 2009 · 16,270 vehicles
What's wrong: These headlamps fail to conform to the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Why it matters: Decreased lighting visibility May result in a vehicle crash.
The fix: Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on May 11, 2009.
Exterior lights Equipment recall #09E025000 · 2009 · 42,540 vehicles
What's wrong: Dope, Inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Why it matters: Decreased lighting visibility May result in a vehicle crash.
The fix: Dope, Inc. will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on July 28, 2009.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 69 mention a fire, 80 injuries and 11 deaths were reported.
What owners describe
- Engine & cooling (219): the most common themes are leaks (70), fire / smoke (32), noise or vibration (28).
- Fuel system (112): the most common themes are leaks (26).
- Brakes (hydraulic) (97): the most common themes are brake failure / soft pedal (27), rust / corrosion (18).
- Body & structure (95): the most common themes are door / lock issues (67), rust / corrosion (15).
The 1999 Ford F-150 has 1044 owner complaints, ranking #16 of 37 F-150 model years for complaints (about average; the typical year has 1025). Complaints peaked in 2000 (128 filed that year). The typical problem showed up when the car was about 5 years old, at a median of 100,000 miles. Neighboring years: 1998 (1381 complaints, 8 recalls), 2000 (1075 complaints, 6 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 4.2 L 6-cyl | Manual 5-spd | Rear-Wheel Drive | 15 | 20 | 17 | Regular |
| 4.2 L 6-cyl | Automatic 4-spd | Rear-Wheel Drive | 14 | 18 | 16 | Regular |
| 4.6 L 8-cyl | Automatic 4-spd | Rear-Wheel Drive | 13 | 18 | 15 | Regular |
| 4.2 L 6-cyl | Automatic 4-spd | 4-Wheel or All-Wheel Drive | 13 | 16 | 15 | Regular |
| 4.2 L 6-cyl | Manual 5-spd | 4-Wheel or All-Wheel Drive | 13 | 17 | 15 | Regular |
| 4.6 L 8-cyl | Manual 5-spd | Rear-Wheel Drive | 13 | 17 | 14 | Regular |
| 5.4 L 8-cyl | Automatic 4-spd | Rear-Wheel Drive | 12 | 16 | 14 | Regular |
| 4.6 L 8-cyl | Automatic 4-spd | 4-Wheel or All-Wheel Drive | 12 | 16 | 14 | Regular |
| 4.6 L 8-cyl | Manual 5-spd | 4-Wheel or All-Wheel Drive | 12 | 16 | 14 | Regular |
| 5.4 L 8-cyl | Automatic 4-spd | 4-Wheel or All-Wheel Drive | 11 | 15 | 13 | Regular |
| 5.4 L 8-cyl | Automatic 4-spd | 2-Wheel Drive | 12 | 15 | 13 | Premium |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 1999 Ford F-150.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 1999 Ford F-150 have any recalls?
Yes. NHTSA lists 7 vehicle recalls for the 1999 Ford F-150, plus 11 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 1999 Ford F-150 problems?
Owners have filed 1044 complaints with NHTSA. The most-reported areas are engine & cooling (219), fuel system (112), brakes (hydraulic) (97).
What gas mileage does the 1999 Ford F-150 get?
EPA ratings run up to 17 mpg combined (4.2 L, Manual 5-spd), across 11 engine and transmission combos.
Where can I get a 1999 Ford F-150 repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.