2003 GMC Safari: Recalls, Problems & MPG
Here are the deets on the 2003 GMC Safari: 1 recall, 18 owner complaints and up to 17 mpg combined.
Recalls
1 vehicle recall from the manufacturer, plus 2 equipment/tire recalls that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Suspension Vehicle recall #03V328000 · 2003 · 41,477 vehicles
What's wrong: Certain minivans have an interference condition between the lower ball joint rubber boot and the steering knuckle (both left/right sides), which could result in cutting of the boot that is intended to seal the ball joint. If the lower ball joint boot were cut, contamination from the road (salt, dirt, water, etc.) could enter the ball socket area of the ball joint causing the joint to wear out too quickly.
Why it matters: The steering knuckle could separate from the lower control arm, dropping down the affected corner of the vehicle. The coil spring would push the control arm down into contact with the ground, creating a drag that would slow the vehicle. The driver could have difficulty in maintaining the…
The fix: Dealers will replace the steering knuckles. Owner notification is expected to begin on April 8, 2004. Owners should contact Chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463.
2 aftermarket equipment / tire recalls replacement parts sold to fit this car, not the car itself
Exterior lights Equipment recall #06E026000 · 2006 · 61,944 vehicles
What's wrong: Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
The fix: Pro-a motors will notify owners and offer to repurchase the lamps. The recall began on April 3, 2006.
Fuel system Equipment recall #06E043000 · 2006 · 88,303 vehicles
What's wrong: Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from October 18, 2005, through March 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). The…
Why it matters: This condition May cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur.
The fix: Honeywell will notify owners and replace the fuel filters free of charge. The recall began on October 18, 2006.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 1 mention a fire, 0 injuries and 0 deaths were reported.
What owners describe
- Brakes (hydraulic) (5): no single recurring theme in the descriptions.
- Transmission & drivetrain (2): no single recurring theme in the descriptions.
- Engine & cooling (2): no single recurring theme in the descriptions.
- Brakes (2): no single recurring theme in the descriptions.
The 2003 GMC Safari has 18 owner complaints, ranking #14 of 16 Safari model years for complaints (well below the 68 average). Complaints peaked in 2003 (4 filed that year). The typical problem showed up when the car was about 2 years old, at a median of 46,400 miles. Neighboring years: 2002 (25 complaints, 1 recalls), 2004 (5 complaints, 0 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 4.3 L 6-cyl | Automatic 4-spd | Rear-Wheel Drive | 15 | 21 | 17 | Regular |
| 4.3 L 6-cyl | Automatic 4-spd | Rear-Wheel Drive | 14 | 19 | 16 | Regular |
| 4.3 L 6-cyl | Automatic 4-spd | Rear-Wheel Drive | 13 | 18 | 15 | Regular |
| 4.3 L 6-cyl | Automatic 4-spd | 4-Wheel or All-Wheel Drive | 14 | 18 | 15 | Regular |
| 4.3 L 6-cyl | Automatic 4-spd | 4-Wheel or All-Wheel Drive | 12 | 16 | 14 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2003 GMC Safari.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2003 GMC Safari have any recalls?
Yes. NHTSA lists 1 vehicle recall for the 2003 GMC Safari, plus 2 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2003 GMC Safari problems?
Owners have filed 18 complaints with NHTSA. The most-reported areas are brakes (hydraulic) (5), transmission & drivetrain (2), engine & cooling (2).
What gas mileage does the 2003 GMC Safari get?
EPA ratings run up to 17 mpg combined (4.3 L, Automatic 4-spd), across 5 engine and transmission combos.
Where can I get a 2003 GMC Safari repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.