2005 Pontiac Grand Am: Recalls, Problems & MPG
Here are the deets on the 2005 Pontiac Grand Am: 2 recalls, 102 owner complaints and up to 25 mpg combined.
Recalls
2 vehicle recalls from the manufacturer, plus 2 equipment/tire recalls that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Suspension Vehicle recall #05V054000 · 2005 · 9,402 vehicles
What's wrong: Certain passenger vehicles equipped with rear suspension knuckle bolts that are not to specification and could fracture under high loads that can occur in some driving conditions.
Why it matters: If the bolt fracture, the rear suspension linkage could detach from the knuckle and the rear wheel would be able to turn inboard or outboard. Sudden changes in vehicle handling could occur, particularly at higher speeds, and the driver May not be able to control the vehicle and a crash could occur…
The fix: Dealers will replace both rear suspension knuckle bolts free of charge. The recall began on February 9, 2005.
Electrical Vehicle recall #14V400000 · 2014 · 5,877,718 vehicles
What's wrong: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General motors LLC (gm) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet impala and monte carlo, 1997-2003…
Why it matters: If the key is not in the run position, the air bags May not deploy if the vehicle is involved in a crash, increasing the risk of injury.
The fix: Gm will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. Gm's number for this recall is 14350.
2 aftermarket equipment / tire recalls replacement parts sold to fit this car, not the car itself
Fuel system (other) Equipment recall #07E021000 · 2007 · 742 vehicles
What's wrong: Certain delphi fuel pressure regulators, p/nos. Fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after January 9, 2007, as aftermarket equipment for various passenger vehicles listed above. The universal pressure regulators (upr) were produced without an o'ring and retainer.
Why it matters: Fuel May leak, possibly resulting in a fire.
The fix: Delphi will notify owners and replace the upr free of charge. The recall began on April 23, 2007. Owners can contact delphi at 877-411-8770.
Exterior lights Equipment recall #09E012000 · 2009 · 16,270 vehicles
What's wrong: These headlamps fail to conform to the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Why it matters: Decreased lighting visibility May result in a vehicle crash.
The fix: Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on May 11, 2009.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 1 mention a fire, 7 injuries and 1 deaths were reported.
What owners describe
- Electrical (40): the most common themes are electrical failure (14), door / lock issues (10), stalls / loses power (10).
- Exterior lights (12): the most common themes are fire / smoke (3), electrical failure (3).
- Fuel system (11): the most common themes are leaks (3), stalls / loses power (3), fire / smoke (2).
- Airbags (10): the most common themes are fails to deploy (6), warning light on (3).
The 2005 Pontiac Grand Am has 102 owner complaints, ranking #14 of 16 Grand Am model years for complaints (well below the 341 average). Complaints peaked in 2014 (27 filed that year). The typical problem showed up when the car was about 6 years old, at a median of 83,000 miles. Neighboring years: 2004 (293 complaints, 2 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 2.2 L 4-cyl | Automatic 4-spd | Front-Wheel Drive | 22 | 31 | 25 | Regular |
| 3.4 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 18 | 27 | 21 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2005 Pontiac Grand Am.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2005 Pontiac Grand Am have any recalls?
Yes. NHTSA lists 2 vehicle recalls for the 2005 Pontiac Grand Am, plus 2 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2005 Pontiac Grand Am problems?
Owners have filed 102 complaints with NHTSA. The most-reported areas are electrical (40), exterior lights (12), fuel system (11).
What gas mileage does the 2005 Pontiac Grand Am get?
EPA ratings run up to 25 mpg combined (2.2 L, Automatic 4-spd), across 2 engine and transmission combos.
Where can I get a 2005 Pontiac Grand Am repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.