1998 Pontiac Sunfire: Recalls, Problems & MPG
Here are the deets on the 1998 Pontiac Sunfire: 3 recalls, 120 owner complaints and up to 25 mpg combined.
.jpg){kind=link}
Recalls
3 vehicle recalls from the manufacturer, plus 4 equipment/tire recalls that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Wheels Vehicle recall #97V219000 · 1997 · 24 vehicles
What's wrong: The wheel lug nuts were not tightened securely resulting in a fracture of the wheel studs.
Why it matters: The wheel could separate from the vehicle. If the vehicle were in motion, a vehicle crash could result.
The fix: Dealers will inspect the torque of all wheel nuts and, if necessary, tighten any that May be below required torque.
Steering Vehicle recall #02V286000 · 2002 · 1,159,156 vehicles
What's wrong: Certain passenger vehicles and MINI vans have lower pinion bearings in the power rack and pinion assembly in which the retainer tabs were not crimped properly. These and some other retainers used in vehicles assembled between January 1, 1996 and October 31, 1997, could fail and permit the ball bearings to escape.
Why it matters: If this occurs, the pinion shaft can be forced upward during left turns and back down as the steering wheel is moved back and to the right. If the pinion shaft moves further, the driver will need to exert more effort to turn the steering wheel, similar to a vehicle without power assisted steering.…
The fix: Dealers will install a new lower pinion bearing unless inspect of the existing bearing indicates that replacement of the gear assembly is necessary. Owner notification began January 24, 2003.
Electrical Vehicle recall #04V036000 · 2004 · 1,415,231 vehicles
What's wrong: On certain passenger vehicles. If the engine fails to start and the driver holds the key in the "start" position for an extended period, high current flows through the ignition switch, and sometimes produces enough heat to melt internal switch parts.
Why it matters: If the switch is damaged, a fire could occur in the steering column, even with the engine off and the key removed. The fire could spread to the interior of the car, which could injure occupants or cause damage to adjoining structures.
The fix: Dealers will install a relay kit in these vehicles to prevent high current from flowing through the ignition switch, and check that your car will start with a properly charged battery and, if necessary, replace the ignition switch. Owner notification will begin on March 1, 2004.
4 aftermarket equipment / tire recalls replacement parts sold to fit this car, not the car itself
Exterior lights Equipment recall #06E026000 · 2006 · 61,944 vehicles
What's wrong: Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
The fix: Pro-a motors will notify owners and offer to repurchase the lamps. The recall began on April 3, 2006.
Fuel system Equipment recall #07E015000 · 2007 · 3,124 vehicles
What's wrong: Certain delphi aftermarket fuel pump modules / module reservoir assemblies (mra) that were sold for use on the above listed vehicles. During production the mras vent and fuel return tubes were reversed. This condition can result in the vehicle not running correctly (idle rough and/or stall) due to an overly rich fuel blend or the vehicle's evaporative emission carbon canister May leak fuel.
Why it matters: A stalled vehicle can increase the risk of a vehicle crash. A fuel leak can result in a fire.
The fix: Delphi will notify owners and replace the defective mras free of charge. The recall began on March 20, 2007. Owners can contact delphi at 1-877-335-7443.
Fuel system (other) Equipment recall #07E021000 · 2007 · 742 vehicles
What's wrong: Certain delphi fuel pressure regulators, p/nos. Fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after January 9, 2007, as aftermarket equipment for various passenger vehicles listed above. The universal pressure regulators (upr) were produced without an o'ring and retainer.
Why it matters: Fuel May leak, possibly resulting in a fire.
The fix: Delphi will notify owners and replace the upr free of charge. The recall began on April 23, 2007. Owners can contact delphi at 877-411-8770.
Steering Equipment recall #08E063000 · 2008 · 3,855 vehicles
What's wrong: 425-151, 425-152, and 425-153, (sold under dorman's "oe solutions" brand name), balkamp #'s 7-3057, 7-3058, 7-3059 (sold under the "napa" brand name), and platinum parts #'s 2425151, 2425152, and 2425153 manufactured during the month of September 2007. These replacement steering shafts can be used on the vehicles listed above. The weld connecting the inner tube to the outer tube May be defective.
Why it matters: If the weld fails, loss of steering could result, possibly resulting in a vehicle crash.
The fix: Dorman will notify owners and replace the steering shafts free of charge. The recall began on October 16, 2008.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 1 mention a fire, 6 injuries and 2 deaths were reported.
What owners describe
- Engine & cooling (32): the most common themes are stalls / loses power (17), electrical failure (4).
- Electrical (21): the most common themes are electrical failure (6), stalls / loses power (5), fire / smoke (4).
- Steering (14): the most common themes are steering problems (10), noise or vibration (4).
- Brakes (hydraulic) (13): the most common themes are brake failure / soft pedal (2).
The 1998 Pontiac Sunfire has 120 owner complaints, ranking #3 of 13 Sunfire model years for complaints (about average; the typical year has 88). Complaints peaked in 2002 (18 filed that year). The typical problem showed up when the car was about 4 years old, at a median of 71,620 miles. Neighboring years: 1997 (190 complaints, 6 recalls), 1999 (93 complaints, 2 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 2.2 L 4-cyl | Manual 5-spd | Front-Wheel Drive | 21 | 31 | 25 | Regular |
| 2.4 L 4-cyl | Manual 5-spd | Front-Wheel Drive | 20 | 30 | 24 | Regular |
| 2.2 L 4-cyl | Automatic 3-spd | Front-Wheel Drive | 20 | 27 | 23 | Regular |
| 2.2 L 4-cyl | Automatic 4-spd | Front-Wheel Drive | 20 | 28 | 23 | Regular |
| 2.4 L 4-cyl | Automatic 4-spd | Front-Wheel Drive | 19 | 30 | 23 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 1998 Pontiac Sunfire.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 1998 Pontiac Sunfire have any recalls?
Yes. NHTSA lists 3 vehicle recalls for the 1998 Pontiac Sunfire, plus 4 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 1998 Pontiac Sunfire problems?
Owners have filed 120 complaints with NHTSA. The most-reported areas are engine & cooling (32), electrical (21), steering (14).
What gas mileage does the 1998 Pontiac Sunfire get?
EPA ratings run up to 25 mpg combined (2.2 L, Manual 5-spd), across 5 engine and transmission combos.
Where can I get a 1998 Pontiac Sunfire repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.