2005 Dodge Grand Caravan: Recalls, Problems & MPG
Here are the deets on the 2005 Dodge Grand Caravan: 5 recalls, 995 owner complaints and up to 20 mpg combined.
Recalls
5 vehicle recalls from the manufacturer, plus 1 equipment/tire recall that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Seat belts Vehicle recall #04V047000 · 2004 · 3,200 vehicles
What's wrong: After performing the ncap test, it was discovered that on certain minivans equipped without the available "stow 'n go" seating option, the right front seat belt retractor assembly May have been improperly assembled.
Why it matters: As a result, the seat belt May not properly restrain the occupant during certain crash conditions, which can increase the risk of injury.
The fix: Dealers will inspect the retractor assemblies and any seat belt assembly that does not have the stake will be replaced. Owner notification began on February 23, 2004. Owners should contact daimlerchrysler at 1-800-853-1403.
Visibility (wipers, glass) Vehicle recall #06V067000 · 2006 · 268,800 vehicles
What's wrong: On certain vans and sport utility vehicles, the front windshield wiper motor armature shaft May break.
Why it matters: During certain operating conditions, loss of front windshield wiping capability could occur, and the driver's vision could be obscured which could result in a crash.
The fix: Dealers will inspect and replace the windshield wiper motor free of charge. The recall began on June 19, 2006, to Dodge durango owners. Minivan owners will be notified during July 2006.
Airbags Vehicle recall #10V008000 · 2010 · 308,950 vehicles
What's wrong: The front crash sensors May crack under certain environmental conditions and allow water to enter into the sensor. This can cause the sensor to become inoperative and illuminate the airbag warning light. These sensors were added to enhance the performance of the airbag system in certain frontal crashes.
Why it matters: If the front crash sensors become inoperative, the driver is immediately alerted by illumination of the airbag warning light and the vehicle should be promptly serviced. Until the vehicle is repaired, the airbags May not provide the enhanced protection in the event of a crash.
The fix: Chrysler will replace the front airbag sensors with a new design. This service will be performed free of charge. The safety improvement campaign will begin during June 2010.
Seats Vehicle recall #10V261000 · 2010 · 2 vehicles
What's wrong: There is a possibility of a defective weld at the joint between the pivoting plate and the pivoting plate pin.
Why it matters: The seat occupant May be injured if the seat base pin were to break.
The fix: Amp will notify owners and repair vehicles free of charge. The safety recall began on June 10, 2010.
Equipment Adaptive/Mobility Vehicle recall #10V271000 · 2010 · 13 vehicles
What's wrong: There is a possibility of a defective weld at the joint between the pivoting plate and the pivoting plate pin.
Why it matters: The seat occupant May be injured if the seat base pin were to break.
The fix: All in one mobility will notify owners and the vehicles will be repaired free of charge. The safety recall began on June 22, 2010.
1 aftermarket equipment / tire recall replacement parts sold to fit this car, not the car itself
Visibility (wipers, glass) Equipment recall #07E104000 · 2007 · 1,657 vehicles
What's wrong: Certain curved tempered replacement glass manufactured by hangzhou safety glass Ltd and supplied to safelite by auto temp Inc., identified as dot-430, and sold for use on certain domestic and foreign vehicles May not break into small pieces as expected of tempered glass and fails to conform to Federal Motor Vehicle Safety Standard no. 205, "glazing materials."
Why it matters: In the event of a vehicle crash, the occupant(s) May be seriously injured by shattered glass.
The fix: Safelite will notify its retail customers and replace the glass free of charge. Retail customers can contact safelite toll free at 1-888-843-2906. Safelite will notify its wholesale customers and reimburse wholesale customers for current inventory and at a specified rate for replacing their…
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 7 mention a fire, 44 injuries and 0 deaths were reported.
What owners describe
- Latches & locks (338): the most common themes are door / lock issues (338).
- Electrical (259): the most common themes are door / lock issues (181), electrical failure (123), stalls / loses power (24).
- Exterior lights (150): the most common themes are electrical failure (21), stalls / loses power (16).
- Airbags (103): the most common themes are warning light on (39), fails to deploy (12).
The 2005 Dodge Grand Caravan has 995 owner complaints, ranking #4 of 31 Grand Caravan model years for complaints (2.3× the average Grand Caravan year). Complaints peaked in 2010 (173 filed that year). The typical problem showed up when the car was about 5 years old, at a median of 65,000 miles. Neighboring years: 2004 (116 complaints, 1 recalls), 2006 (284 complaints, 3 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 2.4 L 4-cyl | Automatic 4-spd | Front-Wheel Drive | 17 | 24 | 20 | Regular |
| 3.3 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 17 | 24 | 20 | Regular |
| 3.3 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 16 | 23 | 19 | Gasoline or E85 |
| 3.8 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 16 | 23 | 18 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2005 Dodge Grand Caravan.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2005 Dodge Grand Caravan have any recalls?
Yes. NHTSA lists 5 vehicle recalls for the 2005 Dodge Grand Caravan, plus 1 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2005 Dodge Grand Caravan problems?
Owners have filed 995 complaints with NHTSA. The most-reported areas are latches & locks (338), electrical (259), exterior lights (150).
What gas mileage does the 2005 Dodge Grand Caravan get?
EPA ratings run up to 20 mpg combined (2.4 L, Automatic 4-spd), across 4 engine and transmission combos.
Where can I get a 2005 Dodge Grand Caravan repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.